Transcript Driver Induction Berrima

BLUE CIRCLE
SOUTHERN CEMENT
BERRIMA WORKS
DRIVER INDUCTION
Developed and circulated May 2007
Developed and circulated May 2007
DRIVER CODE OF CONDUCT
• Applies to anyone driving a vehicle on Site
• Requires drivers to hold current valid licenses
• Provides for penalties &/or disciplinary action
to be taken for non compliance eg warning
notice, suspension or cancellation of service
contract or business arrangements
• Covers: times of operation, preferred routes,
parking restrictions, location of school bus
routes
Developed and circulated May 2007
TRUCK ENTRY/EXIT
ALL TRUCKS MUST ENTER &
EXIT THE BERRIMA SITE Via
GATE 2 (Security Gate) ie THE
WEIGHBRIDGE
ENTRY
OFF
TAYLOR AVE (see Green Arrow
next slide)
Developed and circulated May 2007
Developed and circulated May 2007
Site Speed Limits as Signposted
50
Developed and circulated May 2007
Seat Belts Must Be Worn At
All Times
When In A Vehicle
Developed and circulated May 2007
Mandatory Personal Protective
Equipment (when NOT inside truck)
1.
2.
3.
4.
Safety Glasses
Safety Boots
Safety Helmet
High Visibility (HiViz) clothing (HiViz Vest as a
minimum)
5. Other designated Australian Standards approved
personal protective equipment where signposted
Developed and circulated May 2007
Plant Security
• Drivers are responsible for the security of
their own equipment.
• BCSC reserves the right to search vehicles
leaving the site.
• Signed authority is required to remove BCSC
equipment from the site.
Developed and circulated May 2007
Alcohol And Other Drugs
Policy
The following points apply to ALL employees &
contractors on site:
•
•
•
•
•
NO alcohol or drugs allowed on site
R.B.T & Drug Tests apply
R.B.T will apply to work groups
Drug Tests done as a blanket test
People over the limit will be asked to leave
the site
Developed and circulated May 2007
Alcohol And Other Drugs
Policy cont’d
The following alcohol limits apply:
Provisional license drivers <0.00% BAC
Operators of heavy vehicles <0.02% BAC
Developed and circulated May 2007
Smoking Policy
All enclosed areas within the plant and any
other areas where a non-smoker may be at
risk of inhaling tobacco smoke are declared
NO SMOKING AREAS
Developed and circulated May 2007
Parking Restrictions
Parking is NOT permitted
Between No Parking signs or in
designated No Parking Areas
On roadway between Machine Shop
& No. 5 Kiln
Developed and circulated May 2007
TIPPERS!
• AFTER tipping a load, Tippers are NOT
permitted to drive forward from the
tipping point until the tip trailer is fully
lowered.
• Non compliance may result in
disciplinary action being taken, eg a
request to immediately leave the site.
Developed and circulated May 2007
During Plant Emergencies
•
No vehicular access permitted to site ie
gates will be closed during an emergency
•
Emergency Hooter will sound
•
Drivers are to stop what they are doing;
return to their vehicles; turn off engine;
remain in cabin & contact CCR (if in
possession of mobile phone)
•
Await further instructions from an
Emergency Warden
Developed and circulated May 2007
Environmental
Requirements
• Report, contain or control all spillages.
• Fuel and oil MUST NOT be allowed to enter
ducts or drains.
• To report spillages contact Shift Process
Controller Ext 262 or outside/mobile
48602262
Developed and circulated May 2007
First Aid Facilities & Requirements
First Aid Room
8 hours per day
Mon – Thurs 7.00am –
3.30pm
Friday
6.00am – 2.30pm
During kiln overhauls
24 hours
Developed and circulated May 2007
First Aid Facilities &
Requirements
• Report all injuries to Berrima Plant First Aid Officer
Ext 333 or outside/mobile calls 48602333
• Report injury to your own supervisor
• Out of normal business hours Ext 262 or
outside/mobile call 48602262
Developed and circulated May 2007